Product ID:276 ELECTRONIC COMPONENT CLEANER (AEROSOL)
MSDS Date:03/20/1998
FSC:7930
NIIN:00N091356
Status Code:A
MSDS Number: CJJMP

Emergency Phone: 1-800-535-5053

Info Phone: 781-438-7000

Cage: 71431

Telephone: 781-438-7000/800-535-5053

Cage: 71431

HYDROTREATED HEAVY NAPHTHA (PETROLEUM); (HYDROTREATED MIXED

CAS: 64742-48-9

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

STEL 30,000 PPM (M). EC#

CAS: 124-38-9

RTECS: FF6400000

OSHA PEL 9000 MG/M3;5000 PPM

ACGIH TLV: 9000 MG/M3;5000 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE EFFECTS: DIRECT EYE CONTACT MAY
RESULT IN EYE IRRITATION. INHALATION OF VAPOR CONCENTRATIONS IN
EXCESS OF 1000 PPM WILL CAUSE EYE & RESPIRATORY TRACT IRRITATION,
DIZZINESS, HEADACHE AND OTHER CE NTRAL NERVOUS SYSTEM EFFECTS.
CHRONIC EFFECTS: PROLONGED OR REPEATED SKIN CONTACT MAY DEFAT SKIN
AND CAUSE SKIN IRRITATION.
Explanation of Carcinogenicity:AS PER 29 CFR 1910.1200 (HAZARD
COMMUNICATION), THERE ARE NO CARCINOGENS IN THIS RPDOUCT AS LISTED
IN NTP, IARC OR OSHA.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PERSONNEL WITH PRE-EXISTING
DERMATITIS ARE GENERALLY AGGRAVATED BY EXPOSURE

First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, ADMINISTER
ARTIFICIAL RESPIRATION. CONTACT MD IMMEDIATELY. SKIN: WASH WITH
SOAP AND WATER. CONTACT MD IF IRRITATION PERSISTS. EYES: FLUSH FOR
AT LEAS T 15 MINUTES WITH LARGE AMOUNTS OF WATER. CONTACT MD IF
IRRITATOIN PERSISTS. INGESTION: DO NOT INDUCE VOMITING. CONTACT MD
IMMEDIATELY. ADVICE TO MD: TREAT SYMPTOMS.

Flash Point Method:CC
Flash Point:=-6.1C, 21.F
Autoignition Temp:=382.2C, 720.F
Autoignition Temp Text:APPROX
Lower Limits:NOT DETERM
Upper Limits:NOT DETERM
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM OR WATER SPRAY.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . COOL EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:PRESSURIZED CONTAINERS WHEN HEATED ARE A
POTENTIAL EXPLOSION HAZARD. HAZARDOUS MATERIALS IDENTIFICATION
SYSTEM RATING: HEALTH - 1; FLAMMABILITY - 3; REACTIVITY - 1.
4=SEVERE HAZ, 3=SERIOUS HAZ, 2=MODE RATE HAZ, 1=SLIGHT HAZ, ,
0=MINIMAL HAZ. HAZ CHEM EMERGENCY ACTION CODE: 2 Y

Spill Release Procedures:EVACUATE AREA. PROVIDE ADEQUATE VENTILATION.
CONTAIN SPILL TO A SMALL AREA. FLUSH AWAY FROM IGNITION SOURCES
WITH WATER. PICK UP WITH ABSORBENT MATERIAL (E.G., SAND, CLAY, ETC)
AND TRANSFER TO A SUITA BLE CONTAINER FOR DISPOSAL. KEEP OUT OF
SEWERS, STREAMS AND WATERWAYS.

Handling and Storage Precautions:DO NOT STORE IN DIRECT SUNLIGHT OR
ABOVE 50C (120F). VAPORS ARE HEAVIER THAN AIR & WILL COLLECT IN LOW
AREAS. KEEP AWAY FROM SOURCES OF IGNITION - NO SMOKING. DO NOT
BREATHE SPRAY. AVOID CONTACT WITH SKIN. USE ONLY IN
WELL-VENTILATED AREAS.
Other Precautions:HIGHLY FLAMM. AS W/ANY ORG SOLV BASED PROD, CARE
SHOULD BE TAKEN TO AVOID EXCESSIVE INHAL OF VAPS. THIS IS ESP
IMPORTANT IN ENCLSD AREA(S) W/POOR VENT. CARE SHOULD BE TAKEN TO
AVOID KEEPING SKIN CONTI NUALLY WET W/THIS PROD. OCCAS SKIN CONT
SHOULD NOT BE DAMAGING, BUT RPTD/PRLNG CONT MAY DEFAT SKIN & POSS
CAUSE DERM.

Respiratory Protection:NOT NORMALLY NEEDED. IF EXPOSURE LIMITS ARE
EXCEEDED, USE A NIOSH APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:NO SPECIAL REQUIREMENTS. IF EXPOSURE LIMITS ARE EXCEEDED,
PROVIDE ADEQUATE VENTILATION.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . IMPERVIOUS CLOTHING AS NECESSARY TO PREVENT SKIN
CONTACT.
Supplemental Safety and Health
PHYSICAL DATA: COEFFICIENT (WATER/OIL): <1. % AROMATICS BY WEIGHT:
<0.01%. WEIGHT PER VOLUME: 5.8 LBS/GAL. SOLUBILITY OTHER THAN
WATER: NONE.

HCC:V2
Boiling Pt:>97.8C, 208.F
Melt/Freeze Pt:<-60.C, -76.F
Vapor Pres:60 MM HG @ 20C
Vapor Density:>1 (AIR=1)
Spec Gravity:0.7 KG/L
Viscosity:1 CST @ 25C.
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:<0.01% @ 25C.
Appearance and Odor:CLEAR LIQUID W/MILD ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS LIKE LIQUID CHLORINE AND CONCENTRATED OXYGEN.
Stability Condition to Avoid:OPEN FLAMES, HEAT, SPARKS AND RED HOT
SURFACES.
Hazardous Decomposition Products:CARBON MONOXIDE, ALDEHYDES AND OTHER
TOXIC FUMES
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:INCINERATE ABSORBED MATERIAL. INCINERATE
PRESSURIZED OR SEALED CONTAINERS IN AN APPROVED FACILITY. CHECK
LOCAL, STATE & FEDERAL REGULATIONS.

Toxicological Information:BASED ON RECENT 2-YEAR MICE SKIN PAINTING
STUDIES AND OTHER AVAILABLE INFORMATION, THE INTERNATIONAL AGENCY
FOR RESEARCH ON CANCER (IARC) CONCLUDED THAT THEY DOES NOT HAVE
ENOUGH INFORMATION TO CLASSI FY BISPHENOL A DIGLYCIDYL ETHER RESIN.
PROLONGED INHALATION OF SILICON DIOXIDE DUST HAS CAUSED SCARRING OF
LUNGS, SHORTNESS OF BREATH AND SILICOSIS. IT IS PRESENT IN THIS
PRODUCT AS A WET MIXTURE WHIC H, IN NORMAL USE, CANNOT BE
SEPARATED. SILICON DIOXIDE IS LISTED AS A CARCINOGEN BY THE
INTERNATIONAL TOXICOLOGY PROGRAM (NTP) AND THE INTERNATIONAL AGENCY
FOR RESEARCH ON CANCER (IARC).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:THE HAZARDOUS INGREDIENTS WILL RAPIDLY EVAPORATE TO THE AIR
IF RELEASED INTO THE ENVIRONMENT. LONG TERM ADVERSE EFFECTS TO
AQUATIC ORGANISMS ARE NOT EXPECTED. THIS SUBSTANCE IS EXPECTED TO
BE REMOVED IN A WASTEWATER TREATMENT FACILITY.

Transport Information:TDG:AEROSOLS, FLAMMABLE, N.O.S., CLASS 2.1,
UN1950. IMDG:AEROSOLS, CLASS 2, UN1950. NOTE:SHIPPED AS DANGEROUS
GOODS IN LTD QTY OF CLASS 2. 120ML (MAX INNER VOL IN METAL,
PLASTIC/GLASS PACKAGING) OR 10 0 ML (B) (AEROSOLS) (IMO GEN
INTRODUCTION, I.M.D.G. CODE-PAGE 0147 SECTION 15.3).
IATA/ICAO:AEROSOLS, FLAMM, N.O.S., CLASS 2.1, UN1950. ADR/RID:1950,
AEROSOLS, 2, 5F, ADR. U.S. DOT:SHIPPING NAME:AEROS OLS, FLAMM. HAZ
CLASS:2.1. UN/NA#: UN1950. PACKAGING GRP #:N/A. EMERGENCY RESPONSE
BOOK NO.12 OR 128. NOTE:SHIPPED AS CONSUMER COMMODITY ORM-D IN
PACKAGING HAVING A RATED CAPACITY GROSS WT OF 88 LBS O R LESS (49
CFR 173.308(H)).

SARA Title III Information:312 HAZARDS: IMMEDIATE; FIRE; PRESSURE
RELEASE. 313 CHEMICALS: NONE.
Federal Regulatory Information:EUROPEAN CLASSIFICATION: F-HIGHLY
FLAMMABLE. RISK PHRASE - 65 - DOES NOT APPLY TO AEROSOLS. CANADIAN
CLASSIFICATION: B-5: FLAMMABLE AEROSOLS.
State Regulatory Information: